Recalls: 2003 - AUTOCAR - WXLL

• NHTSA Campaign ID Number: 03V491000 - STEERING:WHEEL AND HANDLE BAR
  Recall Date: 12/10/2003

  Summary:
  ON CERTAIN DUAL STEER TRUCKS, THE RIGHT HAND STEERING WHEEL MAY NOT BE SEATED PROPERLY ON THE COLUMN SHAFT.
  
  Manufacturer that filed the Recall:
  AUTOCAR, LLC
  
  Consequence:
  THIS COULD ALLOW THE STEERING WHEEL TO SLIP ON THE STEERING COLUMN SHAFT RESULTING IN LOSS OF VEHICLE STEERING WITHOUT WARNING, WHICH COULD CAUSE A CRASH.
  
  Remedy:
  DEALERS WILL RE-INSTALL STEERING WHEELS NOT MEETING THE SPECIFIED DIMENSION. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING DECEMBER 2003. CUSTOMERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUTOCAR AT 1-765-489-5499.

• NHTSA Campaign ID Number: 03V493000 - POWER TRAIN
  Recall Date: 12/03/2003

  Summary:
  ON CERTAIN TRUCKS EQUIPPED WITH ALLISON HEAVY DUTY TRANSMISSIONS, THE BOLTS FASTENING THE PROPSHAFT TO THE TRANSMISSION YOKE WERE NOT TIGHTENED SUFFICIENTLY. LOOSE BOLTS CAN CAUSE DISLOCATION OF THE PROPSHAFT.
  
  Manufacturer that filed the Recall:
  AUTOCAR, LLC
  
  Consequence:
  THIS CONDITION COULD CAUSE THE VEHICLE TO LOSE POWER TO ITS WHEELS AND RESULT IN A CRASH.
  
  Remedy:
  DEALERS WILL INSPECT AND RE-TIGHTEN BOLTS TO THE REQUIRED SPECIFICATIONS . CUSTOMERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AUTOCAR AT 1-765-489-5499.

• NHTSA Campaign ID Number: 04V390000 - WHEELS:LUGS/NUTS/BOLTS
  Recall Date: 08/11/2004

  Summary:
  ON CERTAIN TRUCKS EQUIPPED WITH ACCURIDE 22.5 X 9.00 - HUB PILOT H.D. STEEL WHEEL RIMS, THE REAR AXLE WHEEL STUDS ARE TOO SHORT. THESE STUDS MAY NOT BE ABLE TO RETAIN THE WHEEL NUT TORQUE AND COULD LOOSEN ALLOWING THE LOSS OF A WHEEL.
  
  Manufacturer that filed the Recall:
  AUTOCAR, LLC
  
  Consequence:
  IF A VEHICLE LOSES A WHEEL WHILE TRAVELING DOWN A ROADWAY, A CRASH COULD OCCUR, PROPERTY DAMAGE TO FOLLOWING VEHICLES OR PERSONAL INJURY TO PERSONS OUTSIDE THE VEHICLE.
  
  Remedy:
  DEALERS WILL REPLACE THE REAR AXLE WHEEL STUDS. THE RECALL BEGAN ON SEPTEMBER 3, 2004. OWNERS SHOULD CONTACT AUTOCAR AT 1-877-973-3486.

• NHTSA Campaign ID Number: 05V032000 - SERVICE BRAKES, AIR:ANTILOCK:ABS WARNING LIGHT
  Recall Date: 02/03/2005

  Summary:
  ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS EQUIPPED WITH BENDIX AUTOMATIC BRAKE SYSTEMS (ABS), THE BRAKES MAY HAVE A SYSTEM FAULT THAT MAY NOT BE DETECTED BY THE ABS ELECTRONIC CONTROL UUNIT (ECU) AND THEREFORE WILL NOT GENERATE AN ABS WARNING LIGHT ON THE DASH OF THE TRUCK.
  
  Manufacturer that filed the Recall:
  AUTOCAR, LLC
  
  Consequence:
  THE ABS BRAKES MAY NOT PERFORM AS DESIGNED AND IN AN ABS ASSISTED STOP THE DRIVER MAY NOT BE ABLE TO MAINTAIN STEERING CONTROL OF THE VEHICLE. WHEN VEHICLE CONTROL IS COMPROMISED THERE IS A CHANCE FOR A CRASH.
  
  Remedy:
  DEALERS WILL INSPECT, RESET AND CHECK THE ECU FOR FAULT LIGHTS AND CHECK THE ABS BRAKES FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 11, 2005. OWNERS MAY CONTACT AUTOCAR AT 1-877-973-3486.

• NHTSA Campaign ID Number: 05V295000 - COMMUNICATIONS:BACK UP ALARM
  Recall Date: 06/24/2005

  Summary:
  ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS, THE BACKUP ALARM MOTION SENSOR MAY NOT HAVE BEEN INSTALLED CORRECTLY AND MAY NOT SENSE WHEN THE VEHICLE MOVERS BACKWARDS UNDER ANY CIRCUMSTANCES.
  
  Manufacturer that filed the Recall:
  AUTOCAR, LLC
  
  Consequence:
  THE VEHICLE MAY ROLL BACKWARDS WITHOUT THE BACKUP ALARM SOUNDING WITH THE RISK OF RUNNING OVER OR CRUSHING A PERSON STANDING OR WORKING BEHIND THE VEHICLE.
  
  Remedy:
  DEALERS WILL REPOSITION THE MOTION SENSOR IN RELATION TO THE MAGNETS THAT ROTATE WHEN THE VEHICLE MOVES. THE RECALL BEGAN ON OCTOBER 19, 2004. OWNERS MAY CONTACT AUTOCAR AT 1-877-973-3486.