Recalls: 2002 - DODGE - DAKOTA

---

Recalls

• NHTSA Campaign ID Number: 03V389000 - ELECTRICAL SYSTEM:WIRING
  Recall Date: 10/15/2003

  Summary:
  ON CERTAIN PICKUP TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS, THE HEADLAMP AND DASH WIRING HARNESS MAY BE CHAFED BY THE ACTUATION OF THE CLUTCH PEDAL. THIS COULD RESULT IN ABNORMAL OPERATION OF THE WIPERS, TURN SIGNALS, HORN OR LIGHTING SYSTEMS.
  
  Manufacturer that filed the Recall:
  CHRYSLER LLC
  
  Consequence:
  THIS COULD AFFECT DRIVER VISIBILITY, COULD PREVENT A DRIVER FROM SOUNDING A WARNING BY USING THE HORN, AND, WHEN THE TURN SIGNALS ARE INOPERATIVE, THE DRIVER CANNOT USE THEM TO SIGNAL INTENT TO TURN, INCREASING THE RISK OF A CRASH.
  
  Remedy:
  DEALERS WILL REROUTE THE WIRE HARNESS AND REPAIR THE HARNESS IF NECESSARY. OWNER NOTIFICATION BEGAN NOVEMBER 3, 2003. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.

• NHTSA Campaign ID Number: 03V505000 - EQUIPMENT:OTHER:LABELS
  Recall Date: 12/11/2003

  Summary:
  ON CERTAIN MINIVANS AND 4X2 PICKUP TRUCKS, THE VEHICLE CERTIFICATION LABEL MAY HAVE GROSS AXLE WEIGHT RATINGS (GAWR) THAT EXCEED THE MAXIMUM TIRE LOAD CAPACITY AS DEFINED IN FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, ¿TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.¿
  
  Manufacturer that filed the Recall:
  CHRYSLER LLC
  
  Consequence:
  IMPROPERLY LOADING YOUR VEHICLE CAN CAUSE TIRE FAILURE AND RESULT IN A CRASH.
  
  Remedy:
  OWNERS WILL BE PROVIDED WITH VEHICLE CERTIFICATION LABEL OVERLAYS CONTAINING CORRECTED INFORMATION RELATIVE TO VEHICLE GAWR AND TIRE SIZE. OWNER NOTIFICATION BEGAN MARCH 1, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-992-1997.

• NHTSA Campaign ID Number: 04V216000 - VISIBILITY:WINDSHIELD WIPER/WASHER
  Recall Date: 05/10/2004

  Summary:
  ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MODULE MOTOR MAY BE SUSCEPTIBLE TO WATER INTRUSION THAT COULD CAUSE INTERNAL CORROSION AND RESULT IN PARTIAL OR COMPLETE LOSS OF FRONT WINDSHIELD WIPING CAPABILITY.
  
  Manufacturer that filed the Recall:
  CHRYSLER LLC
  
  Consequence:
  DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
  
  Remedy:
  DEALERS WILL REPLACE THE FRONT WINDSHIELD WIPER MODULE. OWNER NOTIFICATION BEGAN ON JULY 12, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

• NHTSA Campaign ID Number: 04V596000 - SUSPENSION:FRONT:CONTROL ARM:UPPER BALL JOINT
  Recall Date: 12/21/2004

  Summary:
  ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS EQUIPPED WITH FOUR-WHEEL DRIVE (4X4), IF MOISTURE LEAKS INTO THE FRONT SUSPENSION UPPER BALL JOINT, EVACUATION OF THE LUBRICANT AND CORROSION OF THE JOINT MAY CAUSE THE JOINT TO WEAR OVER AN EXTENDED PERIOD OF TIME. THIS COULD CAUSE A CLUNKING NOISE IN THE FRONT SUSPENSION, WHICH MAY NOT ALWAYS BE HEARD BY THE VEHICLE OCCUPANTS.
  
  Manufacturer that filed the Recall:
  CHRYSLER LLC
  
  Consequence:
  EXCESSIVE WEAR IN THE UPPER BALL JOINT MAY ALLOW IT TO SEPARATE, WHICH COULD RESULT IN LOSS OF CONTROL OF THE VEHICLE.
  
  Remedy:
  DEALERS WILL REPLACE THE FRONT SUSPENSION UPPER BALL JOINTS. THIS SAFETY IMPROVEMENT CAMPAIGN BEGAN ON DECEMBER 21, 2004. OWNERS CAN CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

• NHTSA Campaign ID Number: 06E011000 - FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
  Recall Date: 02/01/2006

  Summary:
  CERTAIN AFTERMARKET AIRTEX ELECTRIC FUEL PUMPS INSTALLED FOR USE AS REPLACEMENT EQUIPMENT FOR CERTAIN 1997-2004 JEEP WRANGLER; 1997-2001 JEEP CHEROKEE; 1997-2004 JEEP GRAND CHEROKEE; AND 2000-2003 DODGE DAKOTA VEHICLES. THE PLASTIC ELECTRICAL GROMMET CONNECTORS AT THE TOP OF THE FUEL PUMP MODULE ARE NOT COMPATIBLE WITH AUTOMOTIVE FUELS AND MAY DEGRADE CAUSING A POTENTIAL LEAK PATH FOR FUEL.
  
  Manufacturer that filed the Recall:
  CHRYSLER LLC
  
  Consequence:
  IN THE PRESENCE OF AN IGNITION SOURCE, A FUEL LEAK COULD RESULT IN A FIRE.
  
  Remedy:
  AIRTEX WILL NOTIFY ITS CUSTOMERS AND WILL REPLACE THE AFFECTED FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 25, 2006. OWNERS MAY CONTACT AIRTEX CUSTOMER SERVICE DEPARTMENT AT 1-800-880-3056.

• NHTSA Campaign ID Number: 06E024000 - ENGINE AND ENGINE COOLING
  Recall Date: 03/17/2006

  Summary:
  CERTAIN REPLACEMENT K&N FUEL PERFORMANCE KITS, P/NOS. 57-1509, 57-1511, 57-1511-1, 57-1517, 57-1517-1, 57-1527, AND 57-1530. ALSO, A SMALL PERCENTAGE OF THESE KITS WERE SOLD UNDER THE MOPAR PERFORMANCE PARTS BRAND NAME (P/NOS. P5007069 AND P5007070). ALL KITS WERE MANUFACTURED FROM APRIL 20, 1999, THROUGH SEPTEMBER 23, 2004. THESE ASSEMBLIES WERE MANUFACTURED AS REPLACEMENT EQUIPMENT FOR CERTAIN DODGE PICKUP TRUCKS AND SUVS. A SMALL PIECE OF MATERIAL FROM THE TUBE WALL COULD BE SUCKED INTO THE ENGINE THROTTLE BODY, WHICH COULD CAUSE THE THROTTLE TO BECOME JAMMED IN THE OPEN POSITION.
  
  Manufacturer that filed the Recall:
  CHRYSLER LLC
  
  Consequence:
  A JAMMED OPEN THROTTLE COULD CAUSE UNINTENDED ACCELERATION OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH OR INCREASED STOPING DISTANCES WHEN BRAKING.
  
  Remedy:
  K&N WILL PROVIDE OWNERS WITH A FREE REPAIR KIT ALONG WITH REPAIR INSTRUCTIONS. THE RECALL BEGAN ON APRIL 20, 2006.

• NHTSA Campaign ID Number: 06E026000 - EXTERIOR LIGHTING
  Recall Date: 03/23/2006

  Summary:
  CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
  
  Manufacturer that filed the Recall:
  MAZDA NORTH AMERICAN OPERATIONS
  
  Consequence:
  WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
  
  Remedy:
  PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.

• NHTSA Campaign ID Number: 06E065000 - EXTERIOR LIGHTING
  Recall Date: 07/17/2006

  Summary:
  CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
  
  Manufacturer that filed the Recall:
  TOYOTA MOTOR NORTH AMERICA, INC.
  
  Consequence:
  LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
  
  Remedy:
  AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.

• NHTSA Campaign ID Number: 07V555000 - POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:COLUMN SHIFT
  Recall Date: 12/11/2007

  Summary:
  ON CERTAIN VAN AND PICKUP TRUCKS EQUIPPED WITH AUTOMATIC TRANSMISSIONS, THE IGNITION/PARK SHIFT INTERLOCK SYSTEM MAY BECOME INOPERATIVE. THIS CAN ALLOW THE SHIFTER TO BE MOVED OUT OF THE "PARK" POSITION WITH THE IGNITION KEY REMOVED (OR IN THE "LOCK" POSITION). THIS CAN ALSO ALLOW THE IGNITION KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE "PARK" POSITION.
  
  Manufacturer that filed the Recall:
  CHRYSLER LLC
  
  Consequence:
  EITHER OF THESE CONDITIONS COULD ALLOW THE VEHICLE TO ROLL AWAY CAUSING A CRASH WITHOUT WARNING.
  
  Remedy:
  DEALERS WILL REPLACE THE GEARSHIFT BLOCKER AND BRACKET ASSEMBLY FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JANUARY 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.