Recalls: 2002 - AMTRAN - FE

---

Recalls

• NHTSA Campaign ID Number: 01V269000 - SEATS
  Recall Date: 09/04/2001

  Summary:
  VEHICLE DESCRIPTION: SCHOOL AND TRANSIT BUSES EQUIPPED WITH 39-INCH FLIP SEATS. THE FLIP SEATS COULD BIND IN THE OCCUPIED POSITION AND NOT RETURN TO THE STORED POSITION WHEN NOT OCCUPIED. THE CUSHION FRAME SUPPORT BAR SLIDES OFF THE SEAT SUPPORT PAD, WHICH COULD RETAIN THE SEAT IN THE OCCUPIED POSITION.
  
  Manufacturer that filed the Recall:
  IC CORPORATION
  
  Consequence:
  THE SEAT COULD BLOCK THE AISLE TO THE EMERGENCY EXIT DURING AN EMERGENCY, WHICH MAY RESULT IN INJURY OR DEATH.
  
  Remedy:
  OWNERS WILL BE PROVIDED WITH INSTRUCTIONS AND PARTS TO REPAIR THE SEATS FREE OF CHARGE. OWNER NOTIFICATION BEGAN OCTOBER 23, 2001. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT AMTRAN AT 800-843-5615.

• NHTSA Campaign ID Number: 01V350000 - ELECTRICAL SYSTEM:WIRING
  Recall Date: 11/15/2001

  Summary:
  VEHICLE DESCRIPTION: CERTAIN BUSES WERE BUILT WITH AN IMPROPER CONNECTION OF THE HEATER HARNESS FROM THE HEATER SWITCH TO THE CONNECTOR JUST OUTSIDE THE HEATER UNIT. THE ASSEMBLY LEFT A LOOSE HOT WIRE IN THE HEATER HARNESS WITH AN UNPROTECTED TERMINAL THAT COULD CAUSE A DIRECT SHORT. THIS WIRE IS PROTECTED WITH A 20-AMPERE CIRCUIT PROTECTION, BUT IN A RARE CASE COULD CAUSE A FIRE.
  
  Manufacturer that filed the Recall:
  IC CORPORATION
  
  Consequence:
  ELECTRICAL COMPONENT FAILURE WITHOUT THE CORRECT PROTECTION IN SOME CASES CAN CAUSE OVERHEATING OF THE COMPONENT.
  
  Remedy:
  OWNERS WILL BE PROVIDED WITH INSTRUCTIONS ON HOW TO REPAIR THE DEFECT. THE REPAIR PROCEDURE FOR THIS DEFECT WILL REQUIRE PLACING THE CONNECTORS CORRECTLY IN THE TERMINALS TO THE HIGH-SPEED BLOWER RELAY AND HARNESS CONNECTION AT THE HEATER. OWNER NOTIFICATION BEGAN DECEMBER 18, 2001. OWNERS WHO DO NOT RECEIVE THE FREE INSTRUCTIONS WITHIN A REASONABLE TIME SHOULD CONTACT AMTRAN AT 1-800-843-5615.

• NHTSA Campaign ID Number: 01V369000 - ELECTRICAL SYSTEM:WIRING
  Recall Date: 12/19/2001

  Summary:
  VEHICLE DESCRIPTION: CERTAIN BUSES WERE BUILT WITH A WIRING DIAGRAM DECAL THAT SHOWS THE CIRCUIT PROTECTION SIZE OF 30 AMPERES INSTEAD OF 20 AMPERES FOR THE HEATER SUPPLY CIRCUITS.
  
  Manufacturer that filed the Recall:
  IC CORPORATION
  
  Consequence:
  ELECTRICAL COMPONENT FAILURE WITHOUT THE CORRECT PROTECTION IN SOME CASES CAN CAUSE OVERHEATING OF THE COMPONENT AND/OR FIRE.
  
  Remedy:
  OWNERS WILL BE PROVIDED WITH A STRIP AND INSTALLATION INSTRUCTIONS THAT SHOULD BE PLACED OVER THE INCORRECT INFORMATION ON THE CURRENT DECAL. OWNER NOTIFICATION BEGAN DECEMBER 21, 2001. OWNERS WHO DO NOT RECEIVE THE FREE STRIP AND INSTALLATION INSTRUCTIONS WITHIN A REASONABLE TIME SHOULD CONTACT AMTRAN AT 1-800-993-7686.

• NHTSA Campaign ID Number: 03V195000 - STRUCTURE:BODY:ROOF AND PILLARS
  Recall Date: 05/28/2003

  Summary:
  CERTAIN SCHOOL BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, ¿BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE.¿ THESE BUSES DO NOT COMPLY WITH THE EMERGENCY EXIT REQUIREMENTS.
  
  Manufacturer that filed the Recall:
  IC CORPORATION
  
  Consequence:
  DURING AN EMERGENCY SITUATION, THIS CONDITION COULD PREVENT PASSENGERS FROM EXITING THE BUS, WHICH COULD CAUSE PERSONAL INJURY OR DEATH.
  
  Remedy:
  DEALERS WILL ADD ONE ROOF EXIT IN THE CENTER OF THE PASSENGER COMPARTMENT. ALL OWNERS HAVE BEEN NOTIFIED AND ARRANGEMENTS MADE TO REMEDY THEIR BUSES.

• NHTSA Campaign ID Number: 03V354000 - STRUCTURE:BODY
  Recall Date: 01/15/2004

  Summary:
  CE MODEL SCHOOL BUSES WHICH FAIL TO COMPLY TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 221, SCHOOL BUS BODY JOINT STRENGTH. THE ROOF TOP SHEET MAY BE IMPROPERLY LOCATED, REDUCING THE MATERIAL EDGE DISTANCE AT THE RIVET LINE.
  
  Manufacturer that filed the Recall:
  IC CORPORATION
  
  Consequence:
  IN THE EVENT OF A VEHICLE CRASH, THE JOINT STRENGHT COULD FAIL POSSIBILY RESULTING IN INJURIES TO THE VEHICLE OCCUPANTS.
  
  Remedy:
  IC WILL NOTIFY ITS CUSTOMERS AND WILL PROVIDE INSPECTION AND REPAIR INSTRUCTION. THE RECALL BEGAN ON JANUARY 25, 2005. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT IC CUSTOMER SERVICE AT (WE DO NOT YET HAVE A TELEPHONE NUMBER FOR THIS CAMPAIGN.)

• NHTSA Campaign ID Number: 04E058000 - EQUIPMENT ADAPTIVE
  Recall Date: 08/13/2004

  Summary:
  CERTAIN SURE-LOK WHEELCHAIR TIE-DOWN SECUREMENT ASSEMBLIES P/N 8625-13 FOR USE ON CERTAIN SCHOOL AND TRANSIT BUSES. THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY MAY BE OUT OF ALIGNMENT CAUSING THE LOAD PAWL NOT TO FULLY SEAT IN THE SPROCKET TEETH.
  
  Manufacturer that filed the Recall:
  IC CORPORATION
  
  Consequence:
  IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES TO THE SEAT OCCUPANT AND/OR OTHER PASSENGERS.
  
  Remedy:
  SURE-LOK WILL NOTIFY ITS CUSTOMERS AND REPLACE THE DEFECTIVE PART FREE OF CHARGE. THE RECALL BEGAN AUGUST 16, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SURE-LOK CUSTOMER SERVICE AT 866-787-3565.

• NHTSA Campaign ID Number: 04V010000 - STRUCTURE:BODY
  Recall Date: 01/15/2004

  Summary:
  CERTAIN FE MODEL SCHOOL BUSES MANUFACTURED FROM OCTOBER 14, 1991, AND MARCH 4, 2003. A GAP BETWEEN THE MODESTY PANEL AND THE WHEEL WELL LOCATED BEHIND THE DRIVER¿S SEAT CAN BE CREATED IF THE PANEL IS BENT OUT OF POSITION. UNDER THE PANEL, THE EDGES ARE SHARP AND JAGGED.
  
  Manufacturer that filed the Recall:
  IC CORPORATION
  
  Consequence:
  SHOULD SOMEONE REACH UNDER THE PANEL, THEY COULD CUT THIER HANDS, FINGERS, OR TOES ON THE JAGGED EDGES.
  
  Remedy:
  IC WILL NOTIFY ITS CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. OWNER NOTIFICATION IS EXPECTED TO BEGIN JANUARY 20, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT IC CORPORATION COMPLIANCE DEPARTMENT TOLL-FREE AT 1-800-843-5615. CUSTOMERS CAN LOCATE THE NEAREST DEALER BY CALLING 1-800-993-7686.

• NHTSA Campaign ID Number: 04V469000 - EQUIPMENT ADAPTIVE
  Recall Date: 09/24/2004

  Summary:
  CERTAIN MY 2001-2005 AMTRAN/IC CORPORATION CE, FE, AND RE SCHOOL BUSES EQUIPPED WITH SURE-LOK WHEELCHAIR TIE-DOWN SECUREMENT ASSEMBLIES P/N 8625-13. THE SPROCKET TEETH OF THE RETRACTOR ASSEMBLY MAY BE OUT OF ALIGNMENT CAUSING THE LOAD PAWL NOT TO FULLY SEAT IN THE SPROCKET TEETH.
  
  Manufacturer that filed the Recall:
  IC CORPORATION
  
  Consequence:
  IN THE EVENT OF A VEHICLE CRASH, THE WHEELCHAIR MAY NOT BE ADEQUATELY SECURED POSSIBLY RESULTING IN INJURIES.
  
  Remedy:
  SURE-LOK WILL NOTIFY IC'S CUSTOMERS AND REPAIR THE BUSES ON IC'S BEHALF AT NO COST TO THE CUSTOMER. THE RECALL BEGAN AUGUST 16, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SURE-LOK AT 1-908-231-1804.

• NHTSA Campaign ID Number: 04V492000 - SEATS
  Recall Date: 10/15/2004

  Summary:
  CERTAIN FE SCHOOL AND COMMERCIAL BUSES BUILT WITH CE WHITE DRIVER SEATS WITH A PEDESTAL STYLE MOUNT AND MANUFACTURED BETWEEN JANUARY 10, 1992 THROUGH FEBRUARY 24, 2004. THESE PEDESTALS CAN DEVELOP CRACKS RENDERING THE SEAT UNSTABLE.
  
  Manufacturer that filed the Recall:
  IC CORPORATION
  
  Consequence:
  IN THE EVENT OF A VEHICLE CRASH, THE SEAT COULD SEPARATE FROM THE BASE, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.
  
  Remedy:
  IC WILL NOTIFY ITS CUSTOMERS AND REPAIR THE SEAT BY REPLACING THE UPPER PORTION OF THE ASSEMBLY WITH A MORE ROBUST DESIGN. THE RECALL BEGAN JUNE 3, 2005. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT IC COMPLIANCE DEPARTMENT AT 1-800-843-5615.

• NHTSA Campaign ID Number: 04V498000 - SEATS
  Recall Date: 10/15/2004

  Summary:
  CERTAIN 1998, 2000-2005 MY CE, FE, AND RE SCHOOL BUSES BUILT WITH ONE OR MORE CE WHITE 30-INCH CHILD RESTRAINT SEATS AND MANUFACTURED BETWEEN MARCH 25, 1998 AND AUGUST 24, 2004. THE SEAT CUSHION RETENTION MAY NOT RETAIN THE SEAT IN ALL CIRCUMSTANCES.
  
  Manufacturer that filed the Recall:
  IC CORPORATION
  
  Consequence:
  IN THE EVENT OF A SUDDEN STOP, THE SEAT CUSHION MAY TIP FORWARD AND MAY BECOME UNATTACHED CAUSING THE PASSENGER TO SLIDE OFF THE SEAT AND/OR BE TRAPPED BY THE SEAT CUSHION. THIS ACTION COULD POSSIBLY RESULT IN PERSONAL INJURY OR DEATH.
  
  Remedy:
  IC CORP WILL NOTIFY ITS CUSTOMERS AND WILL REPAIR THE CUSHION BY ADDING A CLIP TO THE CUSHION TYING IT TO THE SEAT FRAME. THE RECALL BEGAN ON OCTOBER 5, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT IC COMPLIANCE DEPARTMENT AT 1-800-843-5615.