Recalls: 2001 - MITSUBISHI - GALANT

---

Recalls

• NHTSA Campaign ID Number: 00V299001 - ENGINE AND ENGINE COOLING:ENGINE
  Recall Date: 10/19/2000

  Summary:
  VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HARNESS FOR THE CRANKSHAFT POSITION SENSOR COULD COME IN CONTACT WITH A NEW PROTECTIVE SHIELD CAUSING A GROUNDED CIRCUIT.
  
  Manufacturer that filed the Recall:
  MITSUBISHI MOTORS NORTH AMERICA, INC.
  
  Consequence:
  PROLONGED WIRING HARNESS CONTACT WITH THE HEAT SHIELD WILL CAUSE THE WIRING INSULATION TO WEAR AND EVENTUALLY TO GROUND OUT. THIS COULD CAUSE THE ENGINE TO DIE-OUT, INCREASING THE RISK OF A CRASH.
  
  Remedy:
  DEALERS WILL RE-ROUTE THE CRANKSHAFT POSITION SENSOR HARNESS.

• NHTSA Campaign ID Number: 00V320001 - FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS
  Recall Date: 10/27/2000

  Summary:
  VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE OUTER LAYER ONLY OF THIS 3-LAYER FUEL RETURN HOSE DOES NOT CONTAIN THE DESIRED OZONE PROTECTION DUE TO A PROCESSING ERROR.
  
  Manufacturer that filed the Recall:
  MITSUBISHI MOTORS NORTH AMERICA, INC.
  
  Consequence:
  THIS HOSE IS CONSIDERED TO BE INADEQUATE.
  
  Remedy:
  DEALERS WILL REPLACE THE FUEL RETURN HOSE.

• NHTSA Campaign ID Number: 00V339000 - ELECTRICAL SYSTEM:WIRING: REAR COMPARTMENT/TRUNK
  Recall Date: 10/27/2000

  Summary:
  VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE ROUTING OF THE WIRING HARNESS UNDER THE RIGHT AND LEFT SIDE OF THE REAR SEAT COULD ALLOW THE HARNESS TO CONTACT THE BODY. THE WIRES IN EACH HARNESS CONTROL THE STOP LAMP CIRCUIT, BACK-UP LAMP CIRCUIT, AND THE TURN LAMP CIRCUIT.
  
  Manufacturer that filed the Recall:
  MITSUBISHI MOTORS NORTH AMERICA, INC.
  
  Consequence:
  IF ANY OF THESE WIRES BECOME SHORT-CIRCUITED, THE INTERIOR LAMPS, TURN SIGNAL LAMPS, AND REAR STOP LAMPS COULD STOP WORKING. THIS WOULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS TURNING OR BRAKING AND COULD LEAD TO A CRASH.
  
  Remedy:
  DEALERS WILL RE-ROUTE AND SECURE THE HARNESSES AND, IF NECESSARY, REPAIR ANY PRE-EXISTING WIRE INSULATION DAMAGE.

• NHTSA Campaign ID Number: 01V005001 - SEATS
  Recall Date: 01/11/2001

  Summary:
  VEHICLE DESCRIPTION: PASSENGER VEHICLES. A NUMBER OF INCORRECT DRIVER SIDE SEAT MOUNTING BOLTS WERE INSTALLED INTO VEHICLES.
  
  Manufacturer that filed the Recall:
  MITSUBISHI MOTORS NORTH AMERICA, INC.
  
  Consequence:
  THE REAR ANCHOR BOLTS SECURING THE DRIVER'S SEAT MAY NOT PROPERLY SECURE THE SEAT AND COULD INCREASE THE RISK OF DRIVER INJURY IN AN ACCIDENT.
  
  Remedy:
  DEALERS WILL INSPECT THE SEAT MOUNTING BOLTS AND THEN REPLACE THE BOLTS IF NECESSARY. OWNER NOTIFICATION BEGAN FEBRUARY 15, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AT 1-800-222-0037.

• NHTSA Campaign ID Number: 01V011001 - POWER TRAIN:AUTOMATIC TRANSMISSION:COOLING UNIT AND LINES
  Recall Date: 01/17/2001

  Summary:
  VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. A HOSE WAS MIS-MANUFACTURED AND COULD WEAKEN OVER TIME, WHICH COULD RESULT IN LEAKAGE OF THE AUTOMATIC TRANSMISSION FLUID.
  
  Manufacturer that filed the Recall:
  MITSUBISHI MOTORS NORTH AMERICA, INC.
  
  Consequence:
  FLUID LEAKAGE FROM THE COOLER HOSES CAN CAUSE TRANSAXLE DRIVEABILITY PROBLEMS AND SMOKE IF THE OIL CONTACTS THE FRONT EXHAUST PIPE.
  
  Remedy:
  DEALERS WILL REPLACE THE HOSE ASSEMBLY FOR THE AUTOMATIC TRANSMISSION OIL COOLER. OWNER NOTIFICATION MAILING WILL BE PHASED OVER A FIVE-MONTH PERIOD STARTING MARCH 26, THROUGH JULY 23, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AT 1-800-222-0037.

• NHTSA Campaign ID Number: 01V069000 - FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
  Recall Date: 03/08/2001

  Summary:
  VEHICLE DESCRIPTION: PASSENGER VEHICLES. A BULGE IN THE FUEL TANK CAUSED BY THE MANUFACTURING PROCESS RESULTED IN THINNING OF THE MATERIAL DURING A WELDING OPERATION, INCREASING THE RISK OF FUEL LEAKAGE.
  
  Manufacturer that filed the Recall:
  MITSUBISHI MOTORS NORTH AMERICA, INC.
  
  Consequence:
  FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
  
  Remedy:
  DEALERS WILL REPLACE THE FUEL TANK ASSEMBLY. OWNER NOTIFICATION BEGAN MARCH 26, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MITSUBISHI AT 1-800-222-0037.

• NHTSA Campaign ID Number: 04V428000 - EQUIPMENT:OTHER:LABELS
  Recall Date: 09/03/2004

  Summary:
  CERTAIN PASSENGER VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, 'OCCUPANT CRASH PROTECTION.' THE BILINGUAL ENGLISH/SPANISH REMOVABLE AIR BAG WARNING LABELS AFFIXED TO THE DASH AND TO THE SUNVISOR DO NOT MEET THE SIZE REQUIREMENTS OF THE STANDARD.
  
  Manufacturer that filed the Recall:
  MITSUBISHI CARIBBEAN
  
  Consequence:
  THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
  
  Remedy:
  MITSUBISHI CARIBBEAN WILL MAIL A CUSTOMER NOTIFICATION LETTER CONTAINING A WRITTEN DESCRIPTION AND A GRAPHIC OF THE BI-LINGUAL DASHBOARD AIR BAG WARNING LABEL. IN ADDITION, ALL CURRENT 2000-2004 NATIVA OWNERS WILL ALSO RECEIVE REPLACEMENT AIR BAG ALERT LABELS FOR THE SUN VISORS. THIS RECALL IS EXPECTED TO BEGIN DURING MARCH OR APRIL 2005. THE NOTIFICATION TO THE NATIVA OWNERS IS EXPECTED TO BEGIN DURING APRIL OR MAY 2005. OWNERS SHOULD CONTACT MITSUBISHI CARIBBEAN AT 1-787-251-8715.