Recalls: 2001 - BRENNER - TANK TRAILER

• NHTSA Campaign ID Number: 01V243000 - STRUCTURE:BODY:BUMPERS
  Recall Date: 07/31/2001

  Summary:
  VEHICLE DESCRIPTION: TANK TRAILERS. THESE TRAILERS FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 223, "REAR IMPACT GUARDS." THE REAR GUARDS HAVE BEEN FOUND TO SUSTAIN 4.6 PERCENT LESS LOAD THAN PRESCRIBED IN THE APPLICABLE REGULATIONS.
  
  Manufacturer that filed the Recall:
  BRENNER TANK, LLC
  
  Consequence:
  THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
  
  Remedy:
  THE LOWER REAR AREA OF THE SUBJECT BUMPERS WILL BE REINFORCED TO WITHSTAND THE SET REGULATORY LOAD. OWNER NOTIFICATION BEGAN AUGUST 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BRENNER AT 1-800-558-9750.

• NHTSA Campaign ID Number: 01V319000 - SERVICE BRAKES, AIR:ANTILOCK
  Recall Date: 10/10/2001

  Summary:
  VEHICLE DESCRIPTION: TRAILERS EQUIPPED WITH BENDIX ANTILOCK BRAKE SYSTEM (ABS) ELECTRONIC CONTROL MODULE (ECU). THE ABS ON THESE VEHICLES DOES NOT CONTAIN THE INDUSTRY STANDARD POWER LINE CARRIER (PLC) CHIP REQUIRED TO PROVIDE AN ABS MALFUNCTION SIGNAL TO THE TOWING VEHICLE AS REQUIRED BY FMVSS NO. 121, "AIR BRAKE SYSTEMS."
  
  Manufacturer that filed the Recall:
  BRENNER TANK, LLC
  
  Consequence:
  WITHOUT THE PLC CHIP IN THE TRAILER ECU MODULE, THE ABS MALFUNCTION SIGNAL TO THE TOWING VEHICLE WILL NOT FUNCTION.
  
  Remedy:
  DEALERS WILL REPLACE THE ECU MODULE. OWNER NOTIFICATION BEGAN OCTOBER 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BRENNER AT 1-800-558-9750.

• NHTSA Campaign ID Number: 02V139019 - SERVICE BRAKES, AIR:SUPPLY:CHECK VALVE
  Recall Date: 09/03/2002

  Summary:
  ON CERTAIN TRAILERS EQUIPPED WITH BENDIX SR-5 TRAILER SPRING BRAKE VALVE ASSEMBLIES, THE MOLDED RUBBER FACE OF THE INLET/EXHAUST VALVE (I/E VALVE) COMPONENT OF THE AFFECTED VALVES CAN SEPARATE FROM THE VALVE'S METAL INSERT. AIR CAN BE TRAPPED BY A SEPARATED I/E VALVE CAUSING IT TO BALLOON AND BLOCK THE EXHAUST PASSAGE OF THE TRAILER SPRING BRAKE CIRCUIT.
  
  Manufacturer that filed the Recall:
  BRENNER TANK, LLC
  
  Consequence:
  THIS CONDITION CAN RESULT IN THE AFFECTED VEHICLES BEING UNABLE TO APPLY THE TRAILER PARKING/EMERGENCY SPRING BRAKES DURING PARKING IN THE EVENT OF A TRAILER SUPPLY LINE FAILURE. UNINTENDED ROLLAWAY COULD OCCUR, POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH TO THE VEHICLE OCCUPANT OR ANY BYSTANDERS.
  
  Remedy:
  BENDIX WILL NOTIFY CUSTOMERS AND PROVIDE A REPAIR KIT AND INSTALLATION INSTRUCTIONS FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BENDIX AT 440-329-9000 OR BRENNER AT 1-800-558-9750.